This pick came after many weeks of research.
Airstream flooring replacement 7 8.
Yes it can be either a frame off replacement or an in place replacement.
Airstream in the 1950 s built the trailer by stretching the insulation over the frame securing down the plywood floor installing the upper frame and outer skin shell and then installing the belly skin.
Build an inner frame and jack the shell up or build a large pulley system and lift the shell off.
Read more best flooring for an airstream or travel trailer.
From our research there are two ways to preform the shell removal.
The frame off is exactly that you remove the belly skins and then unbolt the upper skin assembly from the floor and then raise it up and pull the floor and frame from under it replace the plywood floor and then lower the skin back down much the way airstream built.
While a shell off floor replacement makes the labor of removing and replacing the floorboards easier it can be difficult for diy ers with limited space or experience.
In our first airstream we chose a vinyl interlocking plank flooring.
It was easy to.
The options were endless.
Whether you need an entire new sub floor or just a patch to fix a broken section we have you covered here at varr vintage airstream restorations and repairs.
New subfloor installation airstream renovation rvliving today we re building the subfloor insulating it with reflectix treating it.
So here s a step by step explanation of how we removed the floor before replacing it.
The removed front floor sections hardly even usable as a template.
The existing vinyl flooring was worn and didn t match the retro trailer.
Very little was holding the shell to the floor or the floor to the frame.
Floor repair replacement.
The airstream definitely needed new flooring.
But in the end we settled on vinyl flooring for our airstream and never regretted it.
This step isn t too hard.
This flooring just clicks into place and should not be fastened to the sub floor either.
Armstrong vct 1948 liner 1948 wee wind 1966 safari 1967 overlander 1976 overlander airstream airstream awning airstream cabinets airstream curtain rods airstream curtains airstream end cap airstream rally airstream rear bath replacement airstream restoration airstream tires airstream upholstery axles baby moons barefoot camp and rv park.
Airstream renovation task 2 lift shell off frame.
Leave about 3 16 of an inch around any walls or obstacles to allow for the expansion.
We spent a while sanding the sticky floor with 3 sanders and removed all the nails.
Vintage airstream trailers that have been neglected for decades usually have a rotten sub floor which can pose as a health hazard and safety concern.
Time to get the full monty underway.
Do we go with a vinyl laminate bamboo hardwood engineered or cork.